Product ID:C/M DYLEK 200 AEROSOL, 5043
MSDS Date:07/31/1991
FSC:6850
NIIN:00N021731
MSDS Number: BLTKH

CERTIFIED LABS

2730 CARL RD
IRVING, TX 75061
US

Emergency Phone: 214-438-1381; 800-527-9929

Info Phone: 214-438-1381

Preparer: R STOLLEY

Cage: 0A649

CERTIFIED LABS DIV OF NCH CORP

152170 IRVING, TX 75015 US

Telephone: 214-438-1381972-438-1381

Cage: 53417

METHANE, DICHLORODIFLUORO-; (DICHLORODIFLUOROMETHANE)

CAS: 75-71-8

RTECS: PA8200000

OSHA PEL 1000 PPM (MFR)

ACGIH TLV: 1000 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHANE, TRICHLOROFLUORO-; (TRICHLOROMONOFLUOROMETHANE)

CAS: 75-69-4

RTECS: PB6125000

OSHA PEL 1000 PPM

ACGIH TLV: C, 1000 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL ALCOHOL

CAS: 64-17-5

RTECS: KQ6300000

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

ETHANE, 1,1,2-TRICHLORO-1,2,2-TRIFLUORO;

CAS: 76-13-1

RTECS: KJ4000000

OSHA PEL 1000PPM;1250 STEL

ACGIH TLV: 1000PPM;1250 STEL

LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SLIGHTLY IRRITATING TO EYES &
CAN DEFAT SKIN. MASSIVE OVEREXPOSURE BY DELIBERATELY CONC &
INHALATION VAPORS CAN LEAD TO CNS DISTURBANCES, SUCH AS DIZZINESS,
NAUSEA, UNCONSCIOSNESS AND DEATH. CH RONIC: REPEATED/PRLNGD CNTCT
W/SKIN CANLEAD TO DERMATITIS. CHLOROFLUOROCARBON MATLS HAVE
PRODUCED (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: SENSITIZATION OF THE MYOCARDIUM TO
EPINEPHRINE IN LAB ANIMALS AND COULD HAVE THE SAME EFFECTS IN
HUMANS. ADRENOMIMETICS (E.G., EPINEPHRINE) MAY BE CONTRAINDICATED
EXCEPT FOR LIFE- SUSTAINING USES IN HUMANS ACUTELY OR CHRONICALLY
EXPOSED TO CHLOROCARBONS OR CFC'S .
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: TYPICALLY NOT A HAZ DUE TO INHERENT LOW TOX & AEROSOL
PACKAGING. IN CASE OF MASSIVE OVEREXP, REMOVE TO FRESH AIR. IF
BRTHG HAS STOPPED, ARTF RESP SHOULD BE STARTED. O2 MAY BE ADMIN. IF
READILY AVAIL. SEEK MED ATTN IMMED. EYE: FLUSH W/LRG AMTS OF H2O
FOR AT LEAST 15 MIN, LIFTING UPPER & LOWER LIDS OCCASIONALLY. GET
MED ATTN. IF IRRIT PERSISTS. TRTMT IS MOST EFFECTIVE WITHIN (SUPP
DATA)

Flash Point Method:CC
Flash Point:NON-FLAMMABLE
Extinguishing Media:FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER SPRAY.
Fire Fighting Procedures:PROD IS NON-FLAM. CHOICE OF EXTINGUISHING
MEDIA DEPENDS ON THE NAUTRE OF THE FIRE. WEAR NIOSH/MSHA APPROVED
PRESSURE DEMAND SCBA & FULL PROT EQUIP .
Unusual Fire/Explosion Hazard:IF AEROSOL CONTAINERS ARE IN A FIRE,
SPRAY WITH H2O TO COOL CANS AND PREVENT RUPTURING. THERMAL DECOMP
PROD MAY INCLUDE FLUORIDES, CHLORIDES & PHOSGENE

Spill Release Procedures:AEROSOL CONTAINER, SO SPILL UNLIKELY. HOWEVER,
IN EXTREME CASES- VENTILATE AREA AND ALLOW SOLVENT TO EVAPORATE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORAGE TEMP: 120 F MAX, 0F MIN. KEEP
AWAY FROM HIGH HEAT. KEEP OUT OF REACH OF CHILDREN.
Other Precautions:READ ENTIRE LABEL BEFORE USING PRODUCT. NO SMOKING IN
AREA OF USE. DO NOT USE IN THE GENERAL VICINITY OF ARC WELDING,
OPEN FLAMES OR HOT SURFACES. HEAT AND/OR UV RADIATION MAY CAUSE THE
FORMATION OF C HLORIDES, FLUORIDES OR PHOSGENE .

Respiratory Protection:DUE TO AEROSOL PACKAGING, A RESPIRATOR IS NOT
NECESSARY. NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN .
Ventilation:GENERAL EXHAUST MORE THAN SUFFICIENT TO KEEP AIR
CONCENTRATION WELL BELOW THRESHOLD LEVELS.
Protective Gloves:NEOPRENE OR RUBBER.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: ONE MINUTE. SKIN: THOROUGHLY WASH EXPOSED AREA WITH
SOAP AND WATER. APPLY EMOLLIENT RICH CREAM. INGEST: INDUCE
VOMITING. KEEP PERSON WARM, QUIET AND GET MEDICAL ATTENTION. NOTE
TO MD: IN CASE OF MASSIVE OVEREXPOSURE. DO NOTGIVE SYMPATHOMIMETIC
DRUGS SUCH AS ADRENALIN.

Boiling Pt:B.P. Text:112F,44C
Vapor Pres:352
Spec Gravity:1.51
Evaporation Rate & Reference:1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WATER WHITE, TRANSPARENT, SLIGHT ALCOHOL ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
FINELY DIVIDED ALUMINUM, RED HOT FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE, HYDROGEN CHLORIDE,
HYDROGEN FLUORIDE. PHOSGENE .

Waste Disposal Methods:DO NOT PUNCTURE OR INCINERATE CAN. DISPOSE OF
EMPTY CAN BY WRAPPING SEVERAL LAYERS OF NEWSPAPWR AND DISPOSE OF IN
TRASH RECEPTACLE. DISPOSAL MUST BE IN ACCORDANCE WITH FEDERAL,
STATE AND LOCAL REGULAT IONS .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.